IMPOSSIBLE TO START THE ENGIN (Engine will not start)
1).Problem : Starter does not rotate or is not powerful
Cause: Discharged battery ,Disconnected, loose, or corroded battery terminals Lowered pilot control shut-off lever. Disconnected, loose, or corroded starter ground line terminals. Faulty pilot control shut-off lever electrical system Too high engine oil viscosity Faulty starter and/or electrical system
Remedy: Charge or replace battery. After repairing the corroded area, securely tighten the connectors. Pull pilot control shut-off lever up. After repairing the corroded area, securely tighten the connectors. See your authorized dealer. Change engine oil with appropriate viscosity. See your authorized dealer.
2).Problem : Starter rotates
Cause: No fuel, Air in the fuel system ,Clogged fuel filter ,Frozen fuel ,Faulty injection pump ,Faulty engine control system ,The emergency engine stop SW is ON., Faulty preheat system
Remedy: After checking that no fuel is leaking, refill fuel. Bleed air. After draining water, replace the element. Warm the fuel pump with hot water or wait until the atmospheric temperature rises. See your authorized dealer. See your authorized dealer. See your authorized dealer. See your authorized dealer.
3).Problem : Even though the engine is started, the engine stalls soon
Cause: Too low idle speed. Clogged fuel filter. Clogged pre-fuel filter. Faulty engine control system. Clogged air cleaner. Faulty injection pump.
Remedy: See your authorized dealer. After draining water, replace the element. Clean or replace the element. See your authorized dealer. Clean or replace the element. See your authorized dealer.
4).Problem : Engine runs irregularly
Cause: Faulty fuel system. Water or air in the fuel system. Faulty engine control system.
Remedy: See your authorized dealer. Drain water or bleed air. See your authorized dealer.
4).Problem : Engine Not Developing Full Powe
Cause: Air filters plugged.Fuel line restricted.Contaminated fuel.Fuel filters plugged.Plugged vent in fuel tank cap.Injection nozzles dirty or malfunctioning.Injection pump linkage adjustment.Wrong oil.Turbocharger failure.Injection pump out of timing.Exhaust restriction.Engine is too hot or cold.Engine failure.Valve clearance.Intake or exhaust system leakage.
Remedy: Replace filter elements.Repair or replace fuel line.Drain fuel tank and clean outlet screen. Refill.Change filters.Clean or install new cap.See your authorized dealer.Use correct fuel.Use correct oil.See your authorized dealer.See your authorized dealer.See below.See your authorized dealer.Check and adjust valves.