Hi! workshop manual,service manual,repair manual [Sign in] [register]

Piper Aztec PA-23-235 APACHE,PA-23-250 AZTEC and six place aztec Service Repair Manual 1964-1981

Revisions to the Aztec Service Manual (P/N 753-564) originally published April 1, 1960 are as follows:

Revisions Publication Date Aerofiche Card Effectivity
CR681001 October 1, 1968 1, 2, 3, 4 and 5
CR720829 August 29, 1972 1, 2, 3, 4 and 5
CR810218 February 18, 1981 1, 2, 3, 4 and 5
PR830426 April 26, 1983 1, 2, 3, 4 and 5
PR860429 April 29, 1986 1
PR860921 September 21, 1986 1
PR040827 August 27, 2004 1 and 3
PR060715 July 15, 2006 1, 2, 3, 4, 5 and 6
PR090101 January 1, 2009 N/A*

This manual generally does not contain hardware callouts for installation. Hardware callouts are only indicated where a special application is required. To confirm the correct hardware used, refer to the PA-23-235/250 Aztec Parts Catalog, P/N 753-522, and FAR 43 for proper utilization. Genuine PIPER parts are produced and inspected under rigorous procedures to insure airworthiness and suitability for use in PIPER airplane applications. Parts purchased from sources other than PIPER, even though identical in appearance, may not have had the required tests and inspections performed, may be different in fabrication techniques and materials, and may be dangerous when installed in an airplane. Additionally, reworked or salvaged parts or those parts obtained from non-PIPER approved sources, may have service histories which are unknown or cannot be authenticated, may have been subjected to unacceptable stresses or temperatures or may have other hidden damage not discernible through routine visual or nondestructive testing. This may render the part, component or structural assembly, even though originally manufactured by PIPER, unsuitable and unsafe for airplane use. Piper Aircraft, Inc. expressly disclaims any responsibility for malfunctions, failures, damage or injury caused by use of non-PIPER approved parts.

  • Covers:INTRODUCTION 1A5
    I AIRWORTHINESS LIMITATIONS 1A35
    II HANDLING AND SERVICING 1B1
    III INSPECTION 1E23
    IV STRUCTURES 1F11
    V SURFACE CONTROLS 1I18A
    VI HYDRAULIC SYSTEM 2A5
    VII LANDING GEAR AND BRAKES 2F23
    VIII POWERPLANT (Normally Aspirated) 3A8
    VIIIA POWERPLANT (Air-Research Turbocharger) 3D17
    VIIIB POWERPLANT (Lycoming Turbocharger) 3H4
    IX FUEL SYSTEM 3I10
    X INSTRUMENTS 4A8
    XI ELECTRICAL SYSTEM 4C1
    XII ELECTRONICS 5A9
    XIII HEATING AND VENTILATION SYSTEM 5B5
    XIV ACCESSORIES AND UTILITIES 5H13

This service manual is effective for PA-23-235, PA-23-250, and PA-E23-250 airplane serial numbers 27-1 thru 27-8154030. This encompasses the following model years:

Model Sub-Model Serial Numbers Model Year
PA-23-250 Aztec 27-1 thru 27-366 1960
27-367 thru 27-504 1961
PA-23-235 Apache 27-505 thru 27-506 1962
27-507 thru 27-587 1963
27-588 thru 27-603 1964
27-604 thru 27-616 1965
27-617 thru 27-622 1966
PA-23-250 Aztec “B” 27-2000 (Prototype) 1961
27-2001 thru 27-2231 1962
27-2232 thru 27-2436 1963
27-2437 thru 27-2504 1964
(or PA-E23-250) Aztec “C” 27-2505 thru 27-2690 1964
27-2691 thru 27-3070 1965
27-3071 thru 27-3508 1966
27-3509 thru 27-3759 1967
27-3760 thru 27-3943, less 27-3837 1968
Aztec “D” 27-3944 thru 27-4042, and 27-3837 1968
27-4043 thru 27-4399 1969
27-4400 thru 27-4564 1970
27-4565 thru 27-4573 1971
Aztec “E” 27-4574 thru 27-4575 1970
27-4576 thru 27-4755 1971
27-4756 thru 27-4866 1972
27-4867 thru 27-4916 (Destroyed 1972 Flood)
27-7304917 thru 27-7305234 1973
27-7405235 thru 27-7405476 1974
27-7554001 thru 27-7554168 1975
Aztec “F” 27-7654001 thru 27-7654203 1976
27-7754001 thru 27-7754163 1977
27-7854001 thru 27-7854139 1978
27-7954001 thru 27-7954121 1979
27-8054001 thru 27-8054059 1980
27-8154001 thru 27-8154030 1981
PA-E23-250 Reduced gross weight 27-2505 thru 27-8154030 1964-1981
to 4995 lbs for
UK market,otherwise same as
standard 5200 lbs models.

 

 

User tags: , , , ,

Related files:

468

Submit a Comment

Your email address will not be published.


*

You may use these HTML tags and attributes: <a href="" title=""> <abbr title=""> <acronym title=""> <b> <blockquote cite=""> <cite> <code> <del datetime=""> <em> <i> <q cite=""> <strike> <strong>